Experimental Study on Frictional and Sealing Performances of Packing Rings in an Oil-free Gas Compre

来源 :Journal of Shanghai Jiaotong University(Science) | 被引量 : 0次 | 上传用户:mahsdbxc
下载到本地 , 更方便阅读
声明 : 本文档内容版权归属内容提供方 , 如果您对本文有版权争议 , 可与客服联系进行内容授权或下架
论文部分内容阅读
To enhance the reliability and to extend service life of packing rings,tribological and sealing performances are investigated based on the experimental results.Friction force,leakage rate and power consumption of three materials of pressure packing seals are measured in a refitted vertical gas compressor.The rings are made of common filled polytetrafluroethylene(Filled PTFE),PTFE reinforced with 30% mass fraction carbon fiber(30%CF+PTFE),and carbon-carbon composites infiltrated with PTFE(C/C+PTFE),respectively.It is found that packing rings will periodically vibrate with the periodic vibration of pressure packing after the travel direction of motion abruptly turns to the reverse direction.Furthermore,the amplitude of vibration slows down with the increasing crank angle.Approximate value of friction force is available by multiple-point fast Fourier transformation(FFT) employed to process the experimental results by reducing the impact of vibration to a great extent.Of three materials of rings employed in experiments,Filled PTFE presents minimal leakage rate accompanied with maximum power consumption.And 30%CF+PTFE exhibits minimum friction power and moderate leakage rate.As for C/C+PTFE,its high mechanical and thermal properties are favorable factors to enhance the ability of operating under high pressure and velocity and to improve the wear resistance.Unfortunately,this also leads to a large leakage rate.Comprehensive consideration should be taken into to evaluate the availability,reliability and service life for a type of packing ring under dry running conditions. To enhance the reliability and extend service life of packing rings, tribological and sealing plays are investigated based on the experimental results. Force force, leakage rate and power consumption of three materials of pressure packing seals are measured in a refitted vertical gas compressor. rings are made of common filled polytetrafluroethylene (Filled PTFE), PTFE reinforced with 30% mass fraction carbon fiber (30% CF + PTFE), and carbon-carbon composites infiltrated with PTFE (C / C + PTFE), respectively. that packing rings will occur vibrate with the periodic vibration of pressure packing after the travel direction of motion abruptly turns to the reverse direction. Focus again, the amplitude of vibration slows down with the increasing crank angle. Appximate value of friction force is available by multiple- point fast Fourier transformation (FFT) employed to process the experimental results by reducing the impact of vibration to a great extent. Of three materials of rings employed in experiments, Filled PTFE presents minimal leakage rate accompanied with maximum power consumption. And 30% CF + PTFE exhibits minimum friction power and moderate leakage rate. As for C / C + PTFE, its high mechanical and thermal properties are favorable factors to enhance the ability of operating under high pressure and velocity and to improve the wear resistance. Unfortunately, this also leads to a large leakage rate. Comprehensive considerations should be taken into to evaluate the availability, reliability and service life for a type of packing ring under dry running conditions.
其他文献
四、脉冲吞咽计数的两种预置方式前面提到数据锁存器对主计数器和吞咽计数器的预置有两种方式,在本节中我们将结合具体电路来分别加以介绍。1. 预置所需分频比的方案当我们
Through hydrothermal process, the chrysanthemum-like ZnO particles are prepared with zinc acetate dihydrate (Zn(CH3COO)2·2H2O) and sodium hydroxide (NaOH) used
SARS得到有效控制后,《紧急状态法》已列入国等院2004年立法项目,年底前将提交全国人大常委会审议。日前,我国防治灾害方面的法律有《传染病防治法》、《突发公共卫生事件应
GPS卫星导航和定位系统,在山区公路隧道测量中发挥着重要作用。这主要依赖于GPS系统可以向全球任何用户全天候地连续提供高精度的三维坐标、三维速度和时间信息等技术参数。
本文报道了具有高光增益的GaAs/Ga_(0.55)Al_(0.45)As异质结光晶体管的研制,并对影响器件光增益的一些因素作了讨论.实验中得到的最大光增益为3350.理论分析和实验结果均表明
针对三黎高速沿线遇到的大量强至中风化板岩,通过压实试验、崩解试验及CBR强度试验研究,表明强至中风化板岩填料具有良好的压实性能,但其抵抗干湿循环及自然风化崩解能力较差
我国汽车零部件再制造试点工作将深化国家发改委2009年5月4日表示,将大力推进产业结构优化升级,通过加大重点工程实施力度、推广高效节能产品以及积极推进循环经济发展等工作
使用金属蒸汽做四波混频实验时,为满足位相匹配要求,通常混入一定数量的缓冲气体[1].使用普通热管炉可以达到此目的,即控制炉温,使金属蒸汽的分压小于所充的缓冲气体的压强.
近年来,新华桥种苗场坚持以科学发展观统领工作全局,努力实现生态建设和经济建设双赢,在调整发展思路,突出发展重点,打造发展亮点的同时,以实施生态建设,大力发展林业特色产
星期天的中午,妈妈正在炒菜,她让我帮她拿个鸡蛋,由于我的手刚摸完带油的东西,手一滑鸡蛋掉进有水的盆里了,这时意想不到的事发生了:鸡蛋竟浮在水面上了。我出于好奇又拿了一
期刊