【摘 要】
：
A high-performance Q370qE-HPS bridge steel with low carbon content(≤0.10wt%),Nb microalloying(0.025-0.050wt%)and low carbon equivalent(CEV)(≤0.38%)has bee
【机 构】
：
State Key Laboratory of Metastable Materials Science and Technology,Yanshan University,No. 438 Hebei
论文部分内容阅读
A high-performance Q370qE-HPS bridge steel with low carbon content(≤0.10wt%),Nb microalloying(0.025-0.050wt%)and low carbon equivalent(CEV)(≤0.38%)has been produced using TMCP procedure.The microstructure and mechanical properties of typical steel plates and layers parallel to rolling surface were characterized.The results show that the microstructure consists of fine-grained quasi-polygonal ferrite(QPF),less pearlite and a large number of fine dispersed Nb-rich precipitates.Consequently,an excellent combination of high strength,high toughness and low yield-to-tensile strength ratio(YR)is obtained.In addition,the QPF grain refinement and pearlite reduction take place simultaneously with increasing distance from central to surface of an identical plate or decreasing thickness of plate,leading to increase in yield strength(Rp0.2),impact energy(EKV2,-40℃)and YR,and approximately the same tensile strength(Rm).The effect of QPF grain size on Rp0.2 and effects of QPF grain size and pearlite area fraction on EKV2(-40℃)can be described by Hall-Petch formula and Boltzmann model,respectively,while the YR is in a good linear relation to QPF grain size and pearlite area fraction.
其他文献
This paper investigated two kinds of corrosion resistant low alloy steels depending on the environment of the North China see(Steel S)and South China sea(St
Ferritic stainless steel is being paid attention by steel industry and downstream users relying on its good over-all properties and low cost.With improvemen
贵州南江水电集团1990年创建时仅是个只有2万元启动资金的供电所,至今已发展成为集发电、供电、供水、商贸于一体,拥有12个子公司和5亿多元资产的产业集团.南江集团的发展,
二氧化氯是一种强氧化性的广谱、安全的杀菌消毒剂，具有用量少、作用快、杀菌率高的特点。消毒过程中不会产生致癌物质，对人体及动物没有危害以及对环境不造成二次污染，二氧化氯
The chemistry composition,process parameters and the test results of Q890D free boron high strength steel plate used for engineering machinery was studied.T
据中国电力企业联合会透露,其已向国务院提出建议实行煤电同步联动,以化解煤价上涨带来的成本增加。而煤炭企业则表示,倘若今年电价再次上调,大约一半的成本支出来自电力的煤
中国药店·片仔癀线上复赛开战!主办单位:中国药店协办单位:片仔癀承办单位:安盛友邦为梦想亮出更优秀的自己初赛告一段落,恭喜进入复赛的你,但晋级也意味着更多的考验。然而
In this paper,different morphology and size of nano epsilon carbides(-carbides)were obtained by low temperature tempering for a low alloy abrasion resistanc
一、4月份经济环境和市场回顾4月份,受政策调控的直接影响,A股市场大幅下挫,上证指数月末报收于2870.61点,跌幅为7.67%,跌破2900点整数关口,两市成交量相较于
First, the ec
The corrosion of pipe is most common problem for oil and gas industry.In this article,three kinds of tubes will be analyzed in terms of their resistance aga